|
地 址：江阴市夏港镇景贤村开发区
电 话：0510-86163799/86032127
传 真：0510-86160577
手 机：13606167137
邮 编：214442 |
|
|
| |
|
|
|
 |
应 用：
本机适用于医药、食品、化工等行业的粉、粒状物料的真空干燥和混合，尤其适用于有下列要求的物料；
1.不能承受高温热敏性物料；
2.容易氧化，有危险的物料；
3.需收回溶剂和有毒气体的物料；
4.要求残留挥发物含量极低的物料；
5.要求混合充分，均匀物料；
The drier is suitable for drying and mixing powder or granule raw
material of pharmaceutical industry, foodstuff industry and
chemical industry and so on. Especially it is suitable for the
folliwing raw materials that have special requirements:
1.thermal sensitive raw material that can not in high temperature;
2.raw materials that are easy to be oxidezed or to be dangerous;
3.raw materials in which the solvent needs to recover and there
is toxic gases;
4.raw material that have the requirement of containing rather low
content of residue volatized materails;
5.raw materials that need to mix evenly and fully. |
双锥回转真空干燥机是集混合、干燥于一体的新型干燥机。将冷凝器、真空泵与干燥机配套，组成真空干燥装置。（如需回收溶剂，冷凝器可不用）本机设计先进，内部结构简单，清洗容易，物料能全部排出，操作简便，物料能全部排出，操作简便，能降低劳动强度改善工作环境。同时因容器本身回转时物料亦转动但器壁上不积料，故传热系数较高，干燥速率大，不仅节约能源，而且物料干燥均匀充分，质量好。可广泛应用于制药、化工、食品、染料等行业物料的干燥。符合“GMP”要求。
Double cone rotating vacuum drier is a new drier that integrates mixing and drying in the one body and equips with condensor and
accumn pump .Therefore the vacuum drier is formed (If the solvent does not recover, the condensor may be not used). The drier is
advanced in design, simple in inner structure, easy for cleaning , to discharge all raw material, convenient in operation, lowing the
strength of labor and improving work environment. Meanwhile raw material is rotating accompanying with the rotating of container, the
wall of container can not accumlate raw make raw material dry evenly and have good quality. It can widely apply to dry raw materials of
pharmaceutical industry, chemical industry, foodstuff industry, dyestuff industry and so on. The equipment is in conformity with the
requirements of “GMP”.
原 理：
SZG双锥回转真空干燥机为双锥形的回转罐体，罐内在真空状态下，向夹套内通入蒸汽或热水进行加热，热量通过罐体内壁与湿物料接触。湿物料吸热后蒸发的水汽，通过真空泵经真空排气管被抽走。由于罐体内处于真空状态，且罐体的回转使物料不断的上下、内外翻动，故加快了物料的干燥速度，提高干燥效率，达到均匀干燥的目的。
Model SZG double cone rotating vacuum drier has double cone rotating tank. Under the state of vacuum inside the tank , pass steam
or hot water into to jacker for heating . The energy can contact with the damp raw material through the inner wall. The vaporized steam
can be pumped out through vacuum exhaust pipe when the damp raw material absorbed heat. Because the inner of tank is in the state
of vacuum and the raw material is turned over all the time caused by the rotating of tank, the dry speed of raw material is quickened and
drying efficiency is raised too and the purpose of uniform dry can be raised. |
|
| |
|
